众富购彩

山东山汽工程机器(团体)无限公司
热线德律风:400-879-1999 山汽官方微信
慎重申明 购机 售后
热线德律风:400-879-1999
您此刻地点的地位: 众富购彩官网> 消息资讯 > 公司消息 >

若何挑选搅拌车的能源装备?

所属分类:公司消息 宣布时候:2021-03-10 来历:众富购彩:http://vncarmart.net 阅读量:18

1.发念头马力的挑选,对统一品牌的发念头,马力越大,加快机能越好,爬坡机能越好、重载时车速越大,运转时换挡的次数越少。是以若是想要你的搅拌车加快快,爬坡机能好,车速高,削减换挡次数,那就更好挑选绝对马力较大的发念头,说的绝对便是恰当的,不能是马力太大,那就会形成华侈的。
1. The choice of engine horsepower. For the same brand of engine, the higher the horsepower, the better the acceleration performance, the better the climbing performance, the higher the maximum speed under heavy load, and the less the number of shifting during operation. Therefore, if you want your mixer to accelerate fast, have good climbing performance, high speed, and reduce the number of shifts, you'd better choose the engine with relatively high horsepower, which is appropriate, not too high horsepower, which will cause waste.
2. 变速箱挑选,普通来讲档的位数越多,1档时爬坡机能越好,档位数越多,换挡时发念头转速变更月小,整车的利用就加倍经济省油;变速器扭矩,变速器的额外输出扭矩不能小于发念头的扭矩,比方WP10.336E40发念头的扭矩为1500Nm,能够婚配10JSD160变速器,可是不能婚配10JSD140变速器。变速箱要携同步器,携同步器的变速器,换挡时齿轮主动吸入,换挡平顺性好,换挡打击小。
two Generally speaking, the more the number of gears, the better the climbing performance in the first gear. The more the number of gears, the smaller the change of engine speed in the shift, the more economical and fuel-efficient the whole vehicle is. The transmission torque, the rated input torque of the transmission should not be less than the maximum torque of the engine. For example, the maximum torque of wp10.336e40 engine is 1500nm, which can be matched with 10jsd160 transmission, But it can't match the 10jsd140 transmission. The transmission should be equipped with synchronizer. The transmission with synchronizer can automatically suck in the gears when shifting, which has good shifting smoothness and small shifting impact.
主动上料搅拌机
3. 车辆后桥的挑选,搅拌车的承载力首要依托后桥,后桥的速比月小,划一前提下车速越高,经济车速越高,经济车速越高,车辆就越省油,可是车辆的爬坡就差点,档加快才能就差些。
3. The choice of the rear axle of the vehicle, the bearing capacity of the mixer mainly depends on the rear axle, the speed ratio of the rear axle is small. Under the same conditions, the higher the maximum speed is, the higher the economic speed is, and the higher the economic speed is, the more fuel-efficient the vehicle is. However, the climbing speed of the vehicle is poor, and the acceleration ability of the highest gear is poor.
4. 单双级强的挑选,单级桥只要主加速器一对齿轮啮合,传动效力高,省油;双级桥有主减和轮边加速两对齿轮啮合,传动效力低,可是半轴上扭矩小,靠得住性比拟高。
4. Single stage and double stage strong selection, single stage bridge only has a pair of main reducer gears meshing, high transmission efficiency and fuel saving; double stage bridge has two pairs of main reducer and wheel side reducer gears meshing, low transmission efficiency, but small torque on the half shaft, high reliability.
5. 能源总成挑选,大功率发念头+间接档+小速比的上风:大功率换挡削减,保障发念头任务在经济转速区,爬坡能源强;间接换挡变速器+小速比后桥能够完成和超速档变速器+大速比后桥不异的更小传动比,两种设置装备摆设经济车速分歧;间接档啮合齿轮数目较少,传动效力较高,节油性好。
five Powertrain selection, advantages of high-power engine + direct gear + small speed ratio: reduced high-power shift, ensuring that the engine works in the economic speed zone, strong climbing power; direct shift transmission + small speed ratio rear axle can achieve the same minimum transmission ratio as overdrive transmission + large speed ratio rear axle, the two configurations have the same economic speed; the number of meshing gears in direct gear is less, and the transmission efficiency is high It's high and fuel saving.
6. 普通环境下常常利用档行驶的搅拌车,倡议利用间接档+小速比设置装备摆设;常常利用次行驶的搅拌车,更好利用超速档+大速比设置装备摆设。
6. Generally, the mixer with the highest driving gear is often used, and it is recommended to use the configuration of direct gear + small speed ratio; the mixer with the lower driving gear is often used, and it is better to use the configuration of overdrive gear + large speed ratio.

 

众富购彩官网 产物 德律风 置顶
云彩店 七星乐官网 QQ爱彩 178彩票网 十大正规平台 500vip