众富购彩

山东山汽工程机器(团体)无限公司
热线德律风:400-879-1999 山汽官方微信
慎重申明 购机 售后
热线德律风:400-879-1999
您此刻地点的地位: 众富购彩官网> 消息资讯 > 行业消息 >

若何处理搅拌车的混凝土凝结?

所属分类:行业消息 宣布时辰:2020-08-28 来历:众富购彩:http://vncarmart.net 阅读量:18

  混凝土水泥搅拌运输车产生毛病的时辰,若不实时将搅拌罐内的混凝土清算出来,时辰一久将会凝结,会给咱们带来很大的经济丧失。那末,你晓得在告急环境下若何清算水泥搅拌车内混凝土吗?
  When the concrete mixer truck breaks down, if the concrete in the mixing tank is not cleaned out in time, it will solidify for a long time, which will bring us great economic losses. So, do you know how to clean the concrete inside the cement mixer in case of emergency?
  方式一:
  Method 1
  1、筹办好告急驱动软管,将毛病混凝土水泥搅拌车熄火,卸下液压马达上的高压油管讨论。
  1. Prepare the emergency drive hose, turn off the failure concrete mixer truck, and remove the high-pressure oil pipe connector on the hydraulic motor.
  2、将救济车熄火,将其液压马达的高压油管卸下,并与毛病车上的对应讨论用告急驱动软管相连。
  2. Turn off the fire of the rescue vehicle, remove the high-pressure oil pipe of its hydraulic motor, and connect it with the corresponding connector on the fault vehicle with emergency drive hose.
  3、策动救济车,将其支配手柄拨至出料地位,毛病车内的商品混凝土即被排挤。
  3. Start the rescue vehicle, turn its control handle to the discharging position, and the commercial concrete in the fault vehicle will be discharged.
  4、告急驱动终了后,将驱动软管卸下,并规复两车原状。
  4. After the emergency drive, remove the drive hose and restore the original state of the two vehicles.
          主动上料搅拌机
  方式二:
  Method 2
  1、若个方式实施有坚苦,则必须接纳以下方式,当即排挤混凝土。
  1. If the first method is difficult to implement, the following methods must be used to discharge the concrete immediately.
  2、在托轮和滚道之间放入木楔,以节制搅拌筒的扭转,必然要注重宁静;将策念头熄火,拆松液压马达的一根高压油管,搅拌筒可自在扭转,节制搅拌筒的扭转,使维修孔转到下部,而后翻开维修孔,清算出筒内混凝土。此时必然要注重宁静,商品混凝土排挤终了后,规复混凝土水泥搅拌车原状。
  2. Put a wooden wedge between the supporting roller and the raceway to control the rotation of the mixing drum. Be sure to pay attention to safety. Turn off the engine and loosen a high-pressure oil pipe of the hydraulic motor. The mixing drum can rotate freely and control the rotation of the mixing drum to make the maintenance hole turn to the lower part, and then open the maintenance hole to clean out the concrete in the cylinder. At this time, we must pay attention to safety, after the discharge of commercial concrete, restore the original state of concrete cement mixer truck.
  3、急清算水泥搅拌车内混凝土是咱们每一个水泥搅拌车司机都应当会的,在水泥搅拌车产生毛病时,实时清算,将丧失降到。
  3. Every cement mixer driver should be able to clean the concrete in the cement mixer truck. When the cement mixer fails, clean it in time to minimize the loss.
  以上是对于搅拌车避免混凝土凝结的处理办法,但愿对大师有所赞助,如您另有其余疑难接待征询咱们的网站。
  The above is about the mixer to prevent concrete solidification measures, hope to help you, if you have other questions, welcome to consult our website.

 

众富购彩官网 产物 德律风 置顶
云彩店 七星乐官网 QQ爱彩 178彩票网 十大正规平台 500vip