众富购彩

山东山汽工程机器(团体)无限公司
热线德律风:400-879-1999 山汽官方微信
慎重申明 购机 售后
热线德律风:400-879-1999
您此刻地点的地位: 众富购彩官网> 消息资讯 > 行业消息 >

混凝土搅拌车拌筒呈现毛病怎样处置?

所属分类:行业消息 宣布时候:2021-01-27 来历:众富购彩:http://vncarmart.net 阅读量:18

凝土搅拌车由汽车底盘、搅拌筒、传动体系、供水装配、全功率取力器、搅拌筒前后支架、加速机、液压传动体系、收支料体系、支配机构等局部构成。其任务道理:经由进程取力装配将汽车底盘的能源掏出,并驱动液压体系的变量泵,把机器能转化为液压能传给定量马达,马达再驱动加速机,由加速机驱动搅拌装配,对混凝土停止搅拌。混凝土搅拌车拌筒不能动弹的缘由及处置方式先容以下:
Concrete mixer truck is composed of truck chassis, mixing drum, transmission system, water supply device, full power take-off, front and rear supports of mixing drum, reducer, hydraulic transmission system, feeding and discharging system, control mechanism, etc. Its working principle: take out the power of the car chassis through the power take-off device, drive the variable displacement pump of the hydraulic system, convert the mechanical energy into hydraulic energy and transfer it to the quantitative motor, the motor drives the reducer, and the reducer drives the mixing device to mix the concrete. The reasons why the mixing drum of concrete mixer cannot rotate and the solutions are as follows:
1、运输进程中有混土壤卡住了,清算清洁就不题目了。
1. If the concrete gets stuck during transportation, there will be no problem after cleaning.
2、液压体系或发念头毛病的处置:
2. Troubleshooting of hydraulic system or engine:
1)翻开混凝土搅拌车搅拌筒检验孔盖,旋松马达上高压软管的管讨论,扭转拌筒使拌筒检验孔斜向下,将砼从混凝土搅拌车搅拌筒检验孔排挤。
1) Open the manhole cover of the mixing cylinder of the concrete mixer, loosen the pipe joint of the high-pressure hose on the motor, rotate the mixing cylinder to make the manhole of the mixing cylinder inclined downward, and discharge the concrete from the manhole of the mixing cylinder of the concrete mixer.
2)将毛病车的高压胶管从马达上卸下,把救济用的高压胶管接上,另外一端接在救济车的油泵上,并将应急用的回油管一端接在毛病车的马达泄油口,回油管另外一端接在救济车的油泵回油口,操纵救济车来节制毛病车拌筒的扭转,将砼排挤。
全主动上料搅拌车
2) Remove the high-pressure hose from the motor, connect the high-pressure hose for rescue, connect the other end to the oil pump of the rescue vehicle, connect one end of the emergency oil return pipe to the motor oil drain port of the fault vehicle, and connect the other end of the oil return pipe to the oil return port of the oil pump of the rescue vehicle. Use the rescue vehicle to control the rotation of the mixing cylinder of the fault vehicle and discharge the concrete.
3、马达产生毛病,处置则较简略,可把救济车的马达卸下装在毛病车上,再将各个油管接好,启动救济车便可将拌筒内的砼排挤。
3. In case of motor failure, the treatment is relatively simple. The motor of the rescue vehicle can be unloaded and installed on the failure vehicle, then the oil pipes can be connected well, and the concrete in the mixing drum can be discharged by starting the rescue vehicle.
混凝土搅拌车产生毛病时应实时判定产生毛病的缘由,采用有用的办法将拌筒内的砼排挤后再处置毛病。
When the concrete mixer truck fails, it is necessary to judge the cause of the failure in time and take effective measures to discharge the concrete in the mixing drum before solving the failure.                         

 

众富购彩官网 产物 德律风 置顶
云彩店 七星乐官网 QQ爱彩 178彩票网 十大正规平台 500vip